Morales Gacitúa, M.; Maldonado Saavedra, M.; Vinnett, L. The Impact of Restricting Air Intake in Self-Aspirated Flotation Cells at Los Pelambres Concentrator. Minerals2023, 13, 1375.
Morales Gacitúa, M.; Maldonado Saavedra, M.; Vinnett, L. The Impact of Restricting Air Intake in Self-Aspirated Flotation Cells at Los Pelambres Concentrator. Minerals 2023, 13, 1375.
Morales Gacitúa, M.; Maldonado Saavedra, M.; Vinnett, L. The Impact of Restricting Air Intake in Self-Aspirated Flotation Cells at Los Pelambres Concentrator. Minerals2023, 13, 1375.
Morales Gacitúa, M.; Maldonado Saavedra, M.; Vinnett, L. The Impact of Restricting Air Intake in Self-Aspirated Flotation Cells at Los Pelambres Concentrator. Minerals 2023, 13, 1375.
Abstract
This article describes the impact of restricting the air intake in industrial 250 m3 WEMCO flotation cells at Los Pelambres concentrator. The influence of this air restriction on the hydrodynamic and metallurgical performance of this type of machine was evaluated. The experiments were conducted in single flotation cells and in entire rougher banks. In all cases, the gas holdup was measured to estimate the effectiveness of the obstruction system to decrease the air concentration. In single cells, axial profiles for solid percentage and particle size were evaluated. In addition, a mass balance was conducted to assess the copper recovery and concentrate features. In individual cells, the air restriction led to a decrease in the gas holdup. However, this slight change was enough to obtain a more stable froth zone and a better solids suspension. The latter was observed as a higher P80 below the pulp-froth interface, a less diluted pulp at this level, a slightly higher Cu recovery, and a coarser concentrate product. A mineralogical analysis of the concentrate sample also showed the presence of coarser liberated Cu-sulfide particles. The results in single cells suggested an improvement in the recovery of coarse particles by a more intense solids suspension. The air intake was also restricted in 3 rougher banks to assess the impact of the air obstruction on the overall performance of the respective circuit. Eleven out of fourteen cells were operated with air restriction, which led to a significant recovery improvement of 0.9%-1.6% (absolute) with a 95% confidence level. Size-by-size mass balances were also conducted for the rougher circuits, which proved that the recovery improvements were justified by the simultaneous increase in the recovery of coarse and fine particles. Thus, a restriction of the air intake showed that the decrease in the gas holdup (and in the bubble surface area flux) was compensated by a better solids suspension and a higher turbulence in the impeller. The former promotes the recovery of coarse particles, whereas the latter improves the interaction between bubbles and fine particles. Further developments are being made to implement a regulatory control strategy to control the air intake in self-aspirated flotation cells, and to use this approach for optimizing industrial flotation banks.
Keywords
Self-aspirated flotation cells; WEMCO cells; flotation banks; air restriction
Subject
Engineering, Mining and Mineral Processing
Copyright:
This is an open access article distributed under the Creative Commons Attribution License which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.